Product ID:MIL-C-16173D GRADE II AMD II (TECTYL 502C)
MSDS Date:01/01/1987
FSC:8030
NIIN:00-118-0666
MSDS Number: BJYDK

MALTER INTERNATIONAL BULK CHEMICAL DIVISION

80 FIRST STREET
GRETNA, LA 70053
US

Emergency Phone: 504-362-3232 OR 800-535-4095

Info Phone: 504-362-3232 OR 800-535-4095

Cage: 27978

MALTER INTERNATIONAL BULK CHEMICAL DIVISION

GRETNA, LA 70053 US

Telephone: 504-362-3232, OR 800-535-4095

Cage: 27978

STODDARD SOLVENT

CAS: 8052-41-3

RTECS: WJ8925000

Fraction By Weight: 30-35%

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM; 9293

ALPHATIC PETROLEUM DISTILLATES

CAS: 64742-53-6

RTECS: PY8036000

Fraction By Weight: 10-15%

OSHA PEL 5 MG/M3/10MG/M3 STEL

ACGIH TLV: 5 MG/M3 (OIL MIST)

PROPELLANT A-70

Fraction By Weight: 21.4%

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Health Hazards Acute and Chronic:OVEREXPOSURE TO THIS MATERIAL (OR ITS
COMPONENTS) HAS BEEN SUGGESTED AS A CAUSE OF THE FOLLOWING EFFECTS
IN HUMANS, CENTRAL NERVOUS SYSTEM EFFECTS.
Effects of Overexposure:EYES:SEVERE IRRIT,REDNESS,TEARING,BLURRED
VISION.SKIN:IRRIT,DEFATTING,DERMATITIS.BREATHING:DIZZINESS,WEAKNESS
,FATIGUE,NAUSEA,HEADACHE/POSS
UNCONSCIOUS/DEATH.SWALLOWING:GASTROINTESTINAL IRRIT,NAUSEA,VO
MITING,DIARRHEA.ASPIRATION OF MAT'L INTO LUNGS DUE TO VOMITING CAN
CAUSE CHEMICAL PNEUMONITIS WHICH CAN BE FATAL.

First Aid:SKIN:THOROUGHLY WASH AREA W/SOAP & WATER.REMOVE CONTAMINATED
CLOTHING.LAUNDER CLOTHING BEFORE RE-USE.EYES:FLUSH W/LARGE AMOUNTS
OF WATER,LIFTING UPPER & LOWER LIDS OCCASIONALLY.GET MED
ATTN.SWALLOWED: DO NOT INDUCE VOMITING,KEEP PERSON WARM,QUIET/GET
MED ATTN.BREATHED:REMOVE TO FRESH AIR.IF BREATHING DIFFICULT,GIVE
OXYGEN.IF BREATHING STOPPED,GIVE CPR.KEEP PERSON WARM,QUIET & GET
MEDICAL ATTN.

Flash Point:100F/37.8C
Lower Limits:1.0
Extinguishing Media:REGULAR FOAM OR CARBON DIOXIDE OR DRY CHEMICAL.
Fire Fighting Procedures:H20/FOAM MAY CAUSE FROTHING WHICH CAN BE
VIOLENT/POSS ENDANGER LIFE ESPECIALLY IF SPRAYED INTO CONTAINERS OF
HOT,BURNING LIQUID.WEAR SCBA/FULL FACEPIECE.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR/TRAVEL ALONG
GROUND/MOVED BY VENT/IGNIT BY HEAT/IGNIT SOURCES AT DISTANT FROM
HANDLING.NEVER USE WELD/CUT TORCH ON/NEAR CONTAINER.

Spill Release Procedures:ELIMINATE IGNIT SOURCES.PERSONS NOT WEARING
PROT EQUIP;EXCLUD FROM AREA.STOP SPILL,DIKE AREA TO PREVENT
SPREADING,PUMP LIQUID TO SALVAGE TANK.REMAINING LIQUID MAY BE TAKEN
UP ON SAND,CLAY,EARTH,FLOOR ABSORB/OTHER ABSORB MAT'L/SHOVELED
INTOCONTAINERS

Other Precautions:CONTAINERS MAY BE HAZARDOUS WHEN EMPTIED.EMPTIED
CONTAINERS RETAIN RESIDUES,OBSERVE ALL PRECAUTIONS.

Respiratory Protection:IF WORKPLACE EXPOS LIMITS OF PRODUCT OR ANY
COMPONENT IS EXCEED,A NIOSH/MSHA APPROVED AIR SUPPLIED RESPIRATOR
IS ADVISED IN ABSENCE OF PROPER ENVIRONMENTAL CONTROL.ENGINEERING
OR ADMINISTRATIVE CONTRO LS SHOULD BE IMPLEMENTED TO REDUCE EXPOS
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL AND/OR LOCAL
EXHAUST) VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Protective Gloves:WEAR RESISTANT:NEOPRENE,NITRILE RUBBBER
Eye Protection:CHEM SPLASH GOGGLES,OTHER SAFETY GLASSES
Other Protective Equipment:NORMAL WORK CLOTHING COVERING ARMS AND LEGS.
Supplemental Safety and Health

HCC:F4
Boiling Pt:B.P. Text:334F,168C
Vapor Pres:2MMHG @68F
Vapor Density:> AIR
Spec Gravity:.871 @ 60F
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:LIQUID
Percent Volatiles by Volume:30-35

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Hazardous Decomposition Products:MAY FORM TOXIC MATERIALS, CARBON
DIOXIDE AND CARBON MONOXIDE, VARIOUS HYDROCARBONS, SULFUR
COMPOUNDS, ETC.

Waste Disposal Methods:ALLOW VOLATILE PORTION TO EVAP IN HOOD.ALLOW
SUFFICIENT TIME FOR VAPORS TO COMPLETE CLEAR HOOD DUCT WORK.DISPOSE
OF REMAIN MAT'L IN ACCORDANCE W/APPLICABLE REGS.LARGE:DESTROY
LIQUID INCINERATION IN AC CORDANCE W/APPLICABLE REGS.DO NOT BURN
CONTAINER.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.